Replacing Opel Corsa Fuel Pump Relay: Step-By-Step Guide

If your Opel Corsa is not starting, it could be due to a faulty fuel pump relay. The fuel pump relay is located in the driver's side footwell, behind the bonnet catch, or in the main fuse box under the bonnet. To check if the relay is working, turn the key in the ignition and listen for a click, which indicates that the relay is open. Then, turn the key off, and you should hear another click as the relay closes. If you don't hear these clicks, try replacing the relay with a functioning one. If that doesn't work, you may need to replace the entire engine fuse box.

The fuel pump relay is likely under the hood

The fuel pump relay is a small but crucial component that ensures the engine's efficiency. It acts as a gateway between the vehicle's electrical and fuel delivery systems. When the ignition is turned on, the fuel pump relay will supply a consistent voltage to the fuel pump. So, problems with the relay will result in the fuel pump malfunctioning, causing start-up issues.

To locate the fuel pump relay, you can start by checking your Opel Corsa owner's manual, which may include a diagram showing the relay's location. If you're unable to find it there, you can look under the hood, typically in the fuse box. The relay box is often located inside the vehicle under the dashboard on the driver's side.

You can also identify the fuel pump relay by using the diagram on the relay box cover or in the manual. The diagram usually labels each relay and fuse, allowing you to compare it with the relays in the box to find the correct one. Additionally, you can listen for the relay by placing the key in the "on" position; you may hear a click from the relay.

If you're still unable to locate the fuel pump relay, you can consult online resources or visit a mechanic for further assistance.

The relay could be behind the driver's kick panel

To replace the fuel pump relay in an Opel Corsa, you may need to remove the glove compartment or check behind the driver's kick panel. The relay could be behind the driver's kick panel, which is the piece behind where the bonnet pull is, so it's to the right of the pedals. You shouldn't need to go upside down to access it, but you may need to remove the glove box to get to it.

The fuel pump relay is purple in some Corsa models. It should have two blue and red wires running through it. You can check if it's working by putting your finger on it and feeling if it's clicking. If it's not clicking, try using a new relay.

If you can't find the relay behind the driver's kick panel, it might be under the bonnet, to the left of the glovebox, or under the scuttle on the driver's side.

The relay might be in the fuse box

The fuel pump relay is an important component of your Opel Corsa's electrical system. It acts as a switch that controls the flow of electricity to the fuel pump, which in turn creates pressure in the fuel lines to push fuel to the combustion engine. When the ignition is turned on, the fuel pump relay supplies a consistent voltage to the fuel pump. Therefore, a faulty relay will result in the fuel pump malfunctioning, causing start-up issues.

The fuel pump relay can usually be found in the fuse box in the engine bay, which is typically a long black box containing various fuses and relays. However, the location of the fuse box can vary depending on the make and model of the car. In some cars, it may be found under the hood, while in others, it could be located under the dashboard or near the trunk.

To locate the fuel pump relay in your Opel Corsa, you can follow these general steps:

• Consult your vehicle's owner's manual. It often includes a detailed diagram of the relay locations. Look for the section on the fuse and relay box.
• Check under the hood or the dashboard for the relay box. Most vehicles have a fuse and relay box in these areas. The relay box is commonly located inside the vehicle under the dashboard on the driver's side.
• Identify the fuel pump relay using the diagram on the relay box cover or in the manual. The diagram usually labels each relay and fuse, so you can compare it with the relays in the box to find the correct one.

It's important to note that the fuel pump relay may be located in a different place in your Opel Corsa. Some sources suggest that it could be in the driver's side footwell or behind the driver's side kick panel. Therefore, it is always a good idea to refer to your vehicle's owner's manual or consult a mechanic if you are unsure.

The crankshaft sensor could be at fault

If your Opel Corsa is not starting, the crankshaft sensor could be at fault. This sensor is crucial for the engine to run smoothly, and a faulty sensor can cause a range of issues, including difficulty in starting the car, a check engine light, and erratic engine performance.

To diagnose a faulty crankshaft sensor, you can use an ohmmeter or a multimeter to check the resistance and voltage at the sensor. If the sensor is faulty, you may need to replace it. However, simply replacing the sensor may not always fix the issue. In some cases, the problem may lie in the alignment of the sensor or a bend in the mounting tag. Therefore, it is important to thoroughly inspect the sensor and its mounting to ensure it is seated correctly and aligned properly.

In addition to a faulty crankshaft sensor, there are several other potential causes for your Opel Corsa's fuel pump issues. Here are some troubleshooting steps and possible solutions:

• Check the fuel pump relay, which is located in the driver's side footwell, behind the bonnet catch, or in the fuse box. Try replacing the relay with a functioning one to see if that solves the problem.
• Inspect the fuel pump itself. The fuel pump in the Opel Corsa is typically located under the back seat. Turn the key in the ignition and listen for a buzzing sound, which indicates that the fuel pump is working. You can also detach the feeder pipes and turn the key to see if petrol is being pumped through the pipes.
• Check the fuel filter, which is usually located underneath the car, following the fuel lines from the tank. A clogged or dirty fuel filter can restrict fuel flow and cause starting issues.
• Inspect the temperature sender unit, which is attached to the side of the cylinder head or located under the coil pack. A faulty temperature sender unit can affect fuel pump performance.
• Check for any tears or dirt in the fuel pump filter, which is usually located under the fuel pump.
• Perform the paper clip test or use a diagnostic tool to check for fault codes in the computer box. This can help identify any underlying issues affecting the fuel pump's operation.

Check the fuel pump fuse

To check the fuel pump fuse of an Opel Corsa, first locate the fuse box. Depending on the year your Corsa was produced, the fuse box location may vary. For the Opel Corsa C (produced between 2000 and 2006), the fuse box is located on the left side in the driving direction, next to the headlight. For the Opel Corsa D (produced between 2006 and 2014), the fuse box is at the front left side of the engine compartment.

Once you have located the fuse box, open it and look for the fuel pump fuse. In the Opel Corsa C, the fuel pump relay is at number R10, and you can also check fuse number 9 with an amperage of 20 Amps. For the Opel Corsa D, the relevant fuse box diagram was not available.

If you are unable to locate the fuel pump fuse or if checking the fuse does not resolve the issue, you may need to consult a mechanic or a car forum for further assistance.

Frequently asked questions